2003 Honda St1300a Recalls

1. Recall Description

   CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.

   Possible Effects

   IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.

   Action

   DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.

   Notes

   HONDA RECALL NO.P65.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

   Recall Manufacture Dates

   2002-03-15 - 2003-09-19

   Vehicles Affected

   36046

2. Recall Description

   ON CERTAIN MOTORCYCLES, THE ROUTING OF SOME WIRE HARNESSES MAY ALLOW A CONNECTOR TO CONTACT AND CHAFE AGAINST THE FUEL TANK.

   Possible Effects

   EVENTUALLY THE CHAFING MAY CAUSE A SHORT CIRCUIT AND BLOW AN IGNITION SYSTEM FUSE. THE ENGINE WILL THEN STALL WITHOUT WARNING, WHICH COULD CAUSE A CRASH.

   Action

   DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR POSITION AND CHECK FOR DAMAGE. IF ANY DAMAGE IS FOUND, DEALERS WILL REPLACE THE NECESSARY PARTS. IF NO DAMAGE IS FOUND, DEALERS WILL REPOSITION THE CONNECTOR, AND MAKE SURE ADEQUATE CLEARANCE EXISTS. THE RECALL BEGAN ON DECEMBER 8, 2004. OWNERS SHOULD CONTACT HONDA AT 1-866-784-1870.

   Notes

   HONDA RECALL NO. P53.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   2002-01-15 - 2003-08-01

   Vehicles Affected

   2185

3. Recall Description

   ON CERTAIN MOTORCYCLES, THE MAIN WIRE HARNESS HAS A GROUND DISTRIBUTION CONNECTOR THAT IS INCORRECTLY ASSEMBLED. SOME ELECTRICAL CIRCUITS MAY OVERHEAT AND SHORT, INCLUDING THE FUEL PUMP.

   Possible Effects

   IF THE FUEL PUMP STOPS WORKING, THE ENGINE WILL STALL WITHOUT WARNING, WHICH COULD CAUSE A CRASH.

   Action

   DEALERS WILL INSPECT THE GROUND DISTRIBUTION CONNECTOR FOR OVERHEATING DAMAGE. IF ANY DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED. IF NO DAMAGE IS FOUND, THE CONNECTORS WILL BE ASSEMBLED PROPERLY. THE RECALL BEGAN ON DECEMBER 8, 2004. OWNERS SHOULD CONTACT HONDA AT 866-784-1870.

   Notes

   CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   2002-01-15 - 2003-08-01

   Vehicles Affected

   4345